Surly Long Haul Disk Trucker Recent conversion

[Patrick10am]

Hi everyone so pleased I found this forum. I have recently converted my Surly LHT using a Bafang 250w motor and 17 amp hour battery. Went out for a ride the other day I enjoyed very much. Completed 29 miles with only using only 25% of the battery. I only used it on hills and but certainly helped a lot on the steepest ones.

My question is. Now only have one chain ring on the front which is a 42T and 9 speed cassette on the back with the largest wheel having 32T I want to change to a 11 speed 46T Cassette to make things a little easier when not relying on the battery, should the battery get too low on longer rides. I would also need to change to flat bars to give more room and accommodate the shifter. Does anyone have any suggestions on a low budget setup that would do the job.

 

[Nealh]

If using a 46t cassette you will probably need a derailleur extender like a Wolf tooth road link or the copy version from SJS Cycles, your derailleur I doubt will be able to handle the extra tooth count without one added.

This cassette come with one.

SUNSHINE-SZ MTB 9 Speed 11-46T Cassette 9s Sprockets 9speed 9v k7 Ratios Compatible With M430 M4000 M590 Mountain Bike - AliExpress 18

Smarter Shopping, Better Living! Aliexpress.com

www.aliexpress.com

 

[Patrick10am]

If using a 46t cassette you will probably need a derailleur extender like a Wolf tooth road link or the copy version from SJS Cycles, your derailleur I doubt will be able to handle the extra tooth count without one added.

This cassette come with one.

SUNSHINE-SZ MTB 9 Speed 11-46T Cassette 9s Sprockets 9speed 9v k7 Ratios Compatible With M430 M4000 M590 Mountain Bike - AliExpress 18

Smarter Shopping, Better Living! Aliexpress.com

www.aliexpress.com

Thanks very much , very helpful.

 

[Nealh]

My 2 x10 gravel bike only had a 11-34 cassette and the gearing wasn't low enough so I added a 42t cassette, the derailleur didn't have the capacity to handle the 42t so it needed extending to allow good changing. I used a Wolf tooth copy and didn't need to do much except adjust the B/stop adjustment to close the gap between the jockey wheel/chain to the cassette cogs.

 

[anotherkiwi]

Which derailleur was that? I am already pretty extreme - 48-36-26 and 11-40 but get away with it because I don't run big:big and little:little chainwheel/cassette combinations. I am looking for a better derailleur because the Alivio is pretty bad, RD-M592 SGS is on my short list.

OP: With a single 42 there shouldn't be any issues with any long SGS derailleur and you can find 9 speed 11-50 cassettes!

 

[Raboa]

Hi,i have this unused Shimano XT long cage rear derailleur spare. part no: RDM772SGS.

Photos not that good as I am using my phone, make me a decent offer and it's yours.

Thanks

 

[Nealh]

Tiagra RD4700 GS medium derailleur.