Search results

Im not sure tbh this is wot i bought. http://m.ebay.co.uk/itm/351245268935

Hi people. Im a bit stuck with a project im working on. I have a speed controller im using to control a 24v dc motor, it had a built in potentiometer that i have unsoldered and replaced with wires. I want to attach a thumb or handgrip throttle but i dont think these have potentiometers in them...

yeah I am gojng to strip it down, trying to keep a couple of spares too for any future problems

Temporary wired in a push button switch on handlebars to get through next couple of days. eBay guy is sure throttle will work so ordered one and see how that goes. Thanks everyone for help and advice

Have had a play. And managed to get motor working, I have to turn key on then connect wires else it goes into diagnostic mode! Will keep my hand near ignition goin home ready to shut off! Found a throttle on eBay just waiting reply from seller to see if its compatible...

Ok cheers no tools at work or multimeter so I think it will be time for eeny meeny miny mo!!

Just broke down on way to work. Pull throttle no power to motor just led's on. Think it is the throttle as when I pull throttle and switch on it won't do diagnostic check. Goin to bridge connector plug on throttle on break later and see if motor kicks in. Their are 3 wires yellow, red and...

The problem their is that when you switch bike on and its on its stand, the wheel doesn't turn slowly/motor pulsig until after you pulled back throttle and let it go.

Ok so I tried running bike on stand with motor only or pedal assist and it isn't cutting out? In the meantime I noticed when its off the ground in motor only and you pull back throttle and close, when the wheel has slowed down to nearly a stop the motor is almost pulsing and keeping the wheel...

Hi thanks all, it cuts out at any speed. It is getting worse I'm sure so hopefully it will make it a bit easier to diagnose. It's fault is their in pedal assist and motor only. I have just checked connections on battery compartment and all seem tight and ok. It is currently on charge then I am...

Be a bit lost without bike, I live 9 miles from work, I work nites too! No buses, couldn't afford taxis. Cannot drive now due to medical reasons, got a young baby so can't rely on wife to ferry me round. All good fun! Can't complain though when the bike goes wrong I owe alot to this bike!

It's an original untampered with bike for sure. The guy I had it off used it about 3 times. It still had the bobbly bits on tyres. The pic I attached before was how I got it like brand new. I have 3 wires coming out speed controller. 1 to motor, 1 to pedal sensor and 1 to throttle. Their are no...

Hi appreciating the advice. It certainly played up more on way to work tonite. Then it can be fine for 10mins. I will check all connections tomorrow, if I have a battery terminal issue would the led lights not go off intermittently? I am keen to strip motor and do a regrease and inspection but...

They just have a cable wrapped in a white protective plastic,I followed the cable and it just goes to brakes, no wires going off to controller. Back to work tonight for 4 nites so the next 80 miles could be fun!

Ok thanks, I wondered throttle possibly? The only thing I have found is that when you pull break levers (either) should the motor cut out? As it doesn't

Hi thanks for advice, when the motor cuts in and out the led lights do not go off. they go from say half to full when motor cuts out , then back to half when motor kicks back in. This motor cutting in and out happens in a split second and can do it about 3 times in one minute. Then it can be...

Thanks for that, I will test each battery tomorrow. It starts cutting out even when batteries are fresh off charge.

Yeah I believe it's same motor, my journey home is 9 miles with some hills and I pedal assist all the way home and its pretty flat by the time I get their! The batteries are Lucas 12ah and only 4 months old. But they do get charged 10 times a week! My fault is doin it with fully charged...

Hi, I have a very intermittent problem starting with my bike. when riding on motor only or pedal assist the motor is cutting out and straight back in again, it does it a couple of times every few minutes. The battery indicator goes back up to full briefly when motor cuts out. I have done a...

Thanks for advice I will do some research on these.